APR RS3 Sedan: Drag Strip and Road Course Testing Update

10/30/2017
10 min read

APR RS3 Sedan: Drag Strip and Road Course Testing Update

10/30/2017
10 min read

For the past several months, our engineers have meticulously tested and tuned the new 2.5 TFSI found in the Audi RS3 Sedan and TTRS. This has included hundreds of dyno pulls, over 40 passes at the drag strip and more than 50 laps around Road Atlanta. You can read more about our testing and instrumentation here: APR RS3 Sedan Testing and Tuning Update!


Drag Strip:



We visited our local drag strip, Montgomery Motorsport Park, to test the factory software vs our development software for the 2.5 TFSI found in our RS3 Sedan. In terms of engine / performance hardware, we tested our software only, leaving items such as the intake, exhaust, intercooler, fueling and more completely stock. The vehicle was equipped with Toyo R888 tires for added grip. Please Note: Date/Time stamps are 55 minutes ahead of the actual time.


First, we ran the stock tune on 93 octane, full weight (DA: ~600 FT):


[email protected]
[email protected]
[email protected]


Next, we flashed the ECU to our development Stage 1 tune on 93 octane, full weight (DA ~800 FT):


[email protected]
[email protected]
[email protected]


Satisfied with these results we added ethanol from the pump and switched to our development Stage 1 ethanol tune and ran full weight for a single pass (DA: ~125 FT):


[email protected]


Lastly we put the RS3 on a 5 minute track diet, pulling the seats, saving around 150 lbs (DA: ~100 FT):


[email protected]
[email protected]
[email protected]


Time Slips:


slips


Road Course Testing:



Following our successful outing at the drag strip, we headed to Road Atlanta for some brutal track testing. Testing on a road course puts the vehicle through some of the most demanding conditions. The engine is run at full tilt lap after lap, putting it through stress otherwise not seen on the road. In doing so, our calibration team is able to learn valuable information about how the engine handles the increased power in demanding situations our customers may experience. We tested each mode, Drive, Sport, and Manual, and were happy with the performance. Our RS3 was outfitted with our development APR 93 and Ethanol ECU Upgrades (as well as stock), APR 19×8.5 forged wheels with a previously used set of Pirelli Trofeo R tires, and APR Development Lowering Springs at full vehicle weight. We use Motul RBF660 brake fluid.


Race Report from our Driver, Ian Baas:


Good Morning,

Thanks for a successful weekend everyone! The Car and Calibration was perfect and I’ve never been more excited about an APR release in my life. Most production street cars I’ve tested almost always show their weak points within 5-10 laps of any high performance track event. The RS3 Sedan excelled during the entire test and I am sure this product will perform flawlessly in street conditions as it sits currently!

I really cannot stress enough how much this car exceeded my expectations!

Best Time:
RS3 Stage 1 (93 Octane Map)
1:45.60 (RA Wet/Dry Conditions)

S3 Stage 3+ (93 Octane Map)
1:39.10 (RA Dry Conditions, earlier in the year)

For Comparison sake these are Rain Times during this year’s Petit Le Mans Practice… Not bad!



APR Engine/Calibration:
A+

Car performed very well during each Octane tested (Stage 1 E85, Stage 1 93, Stock). Power was strong and on demand throughout each outing. (+/- 10 laps per outing. 55 laps in total.)
Engine Cooling was nominal, I saw little to no fluctuation, holding 240F throughout every run.

Stock Transmission:
B+

By far the best VAG DSG I’ve driven. Transmission performed better than expected in Sport Mode and Manual Mode. Sometimes I could feel small delays in power delivery during apex out throttle application while in Sport Mode. For once I preferred Manual Mode for track driving, the DSG did just about everything you told it to do without electronic intervention. The only intrusive issue I experienced was while exiting turn 8 in 2ndgear, the transmission bounced off the rev-limiter for period of time and would not up-shift until I lifted off the throttle. This was during the last session of the day when I was giving Tyler a ride around the track and the fuel level was almost empty.

Suspension with APR Development Springs:
B+

Without having any comparison to stock spring package it’s hard to say if the car was improved by the addition of APR springs but I can certainly say that the car did not have any glaring unwanted characteristics. We had changing track conditions all day long and the car handled them very well. The car was very neutral from apex out and inspired confidence throughout the track. Even though power output had been increased significantly, corner exit was especially good delivering just the right amount of power for a neutral exit. Corner entry/ Body roll could be better the rear did have the tendency to roll over and cause a slight over steer. I would be very interested in testing stiffer Anti-Roll Bars both independently and Front and Rear Together.

Stock Brakes:
B+

I rarely pressured the brake zones due to poor weather conditions. The only negative experience was a soft/long brake pedal after momentary short stops in pit lane (under 2 mins). The pedal would come back after about a half lap but this is something I would like to address.


– – – – – – – –


Thank you for following our updates. We’ll provide more testing data, such as final power figures, at our upcoming official release!


Go APR!

generic

1349 Posts